Regulations on safe use of chemicals in the hottes

  • Detail

Provisions on the safe use of chemicals in the workplace Chapter 1 General Provisions Article 1 in order to ensure the safe use of chemicals in the workplace and protect the safety and health of workers, these Provisions are formulated in accordance with the labor law and relevant regulations

Article 2 this regulation is applicable to units and personnel that produce, operate, transport, store and use chemicals

Article 3 the use of chemicals in the workplace as mentioned in these Provisions refers to the work activities in which workers are exposed to chemicals due to work; The term "chemicals" as mentioned in these Provisions refers to various chemical substances, compounds or mixtures; The dangerous chemicals mentioned in these Provisions refer to the commonly used dangerous chemicals classified according to the national standard gb13690

Article 4 the units that produce, operate, transport, store and use hazardous chemicals shall publicize the protection knowledge of hazardous chemicals and the first aid methods for chemical accidents to the surrounding units and residents

Article 5 the labor administrative departments of the people's governments at or above the county level shall supervise and inspect the safe use of chemicals in workplaces within their respective administrative areas

Chapter II responsibilities of production units

Article 6 production units shall implement the safety management system for chemical enterprises and relevant national regulations and standards, and register hazardous chemicals with the chemical administrative department

Article 7 the production unit shall identify the hazards of the chemicals produced and mark them

Article 8 production units shall hang "safety labels of hazardous chemicals" (hereinafter referred to as "safety labels") on the hazardous chemicals they produce and fill in "safety technical specifications of hazardous chemicals" (hereinafter referred to as "safety technical specifications")

Article 9 the production unit shall use "safety weekly card" or "safety sign" to indicate the danger of hazardous chemicals at the operation site

Article 10 when a production unit produces hazardous chemicals, it may not fill in the relevant contents after being approved by the chemical registration department if it involves trade secrets when filling in the safety technical instructions, but it must list the main hazardous characteristics of the hazardous chemicals

Article 11 the safety technical instructions shall be replaced every five years. If new hazard characteristics are found during this period, within half a year after the release of relevant information, the production unit must modify the safety technical specification accordingly and provide it to the operation, transportation, storage and use units

Chapter III responsibilities of user unit

Article 12 the chemicals used by the user unit shall be marked by 30 college students of Zhejiang University of technology, the hazardous chemicals shall have safety labels, and the safety technical instructions shall be provided to the operators

Article 13 when purchasing hazardous chemicals, the user must check the safety label on the package (or container). If the safety label falls off or is damaged, it shall be subsidized after inspection and confirmation

Article 14 when the chemicals purchased by the user need to be transferred or sub packed to other containers, their contents shall be marked. For hazardous chemicals, safety labels shall be attached to the containers after transfer or subpackage; The original safety label of the container containing hazardous chemicals shall not be replaced before purification treatment

Article 15 the user unit shall regularly detect and evaluate the hazards caused by the hazardous chemicals used in the workplace, and the detection and evaluation results shall be authorized by the China Plastics Association and the Special Committee on modified plastics; Scientific research and experiment production base rdquo; And ldquo; Functional heavy calcium carbonate production base rdquo; File. The concentration of hazardous chemicals exposed to operators shall not be higher than the national standards; If it is not specified temporarily, the user shall use it under the condition of ensuring safe operation

Article 16 the user unit shall eliminate, reduce and control the hazards caused by hazardous chemicals in the workplace through the following methods:

(1) select non-toxic or low toxic chemical substitutes

(II) select technologies that can eliminate or reduce hazards to the minimum

(III) adopt engineering control measures that can eliminate or reduce hazards (such as isolation, sealing, etc.)

(IV) adopt operation system and operation time that can reduce or eliminate hazards

(V) take other labor safety and health measures

Article 17 the user shall set up first-aid facilities in the workplace of hazardous chemicals and provide emergency treatment methods

Article 18 the user shall eliminate chemical wastes and clean the waste containers containing hazardous chemicals in accordance with relevant national regulations

Article 19 the using unit shall indicate the danger of the equipment containing, transporting and storing hazardous chemicals in the form of color, label, label, etc

Article 20 the using unit shall disclose the safety and health data related to hazardous chemicals to the employees, educate the employees to identify the safety labels, understand the safety technical specifications, master the necessary emergency handling methods and self-help measures, and regularly educate and train the employees on the safe use of chemicals in the workplace

Article 21 chemicals operated by business units shall be marked. The hazardous chemicals operated must have safety labels and safety technical specifications. When importing hazardous chemicals, safety technical specifications shall be provided to the foreign party. For hazardous chemicals prohibited in China but required by the foreign party, the prohibited matters and reasons shall be explained to the foreign party

Article 22 the transport unit must implement the national standards and relevant regulations such as the general technical conditions for the transport and packaging of dangerous goods and the marks for the packaging of dangerous goods, and has the right to require the shipper to provide the safety technical instructions for dangerous chemicals

Article 13 the storage of hazardous chemicals must comply with the national standards and relevant regulations of the general rules for the storage of dangerous chemicals in common use

Chapter V obligations and rights of employees

Article 24 employees shall abide by the labor safety and health rules and regulations and safe operation procedures when the friction coefficient of the workpiece is greater, and shall timely report that it may cause

Copyright © 2011 JIN SHI